第30卷第9期
2017年9月环境科学研究Research of Environmental Sciences Yol. 30,No. 9 Sep.,2017韦超，夏训峰，王京刚，等.回转窑热解气化炉处理生活垃圾特性[】].环境科学研究，2017,30(9):1471-1478. 844vvWEI Chao,XIA XunfengjWANG Jinggang,ef al. Gasification and pyrolysis characteristics of household garbage in a rotary kiln gasifier [ J ] • Research of Environmental Sciences ，2017,30(9) : 1471-1478.
1. 中国环境科学研究院，国家环境保护地下水污染过程模拟与控制重点实验室，北
京100012
2. 北京化工大学化学工程学院，北京100029摘要：基于目前固定床热解气化法在常温下进行存在燃气热值和气化效率较低、燃料适用范围小和预处理复杂等问题，采用控 制变量法设计探究了不同预热空气温度和过量空气系数对小型回转窑式热解气化炉处理村镇生活垃圾的影响.结果表明：预热 空气温度升髙有利于垃圾热解气化产气，但有一定的局限性，当温度超过600 °C 时垃圾的气化产气明显下降；当过量空气系数为0.4时，垃圾的热解气化效率达到最大值，并且焦油产量最小.垃圾原样在过量空气系数为0.4、空气预热温度为500 °C 下对底 渣、飞灰进行重金属含量的分析测试结果显示，飞灰中的铅含量远高于GB 18598—2001《危险废物填埋污染控制标准》相关标准 限值，需要经过处理才能排放，二嗯英采样 分析结果显示其含量均低于GB 18485 —2014《生活垃圾焚烧污染控制标准》限值.研 究显示，该回转窑式热解气化工艺处理生活垃圾的最佳过量空气系数为0.4，最佳空气预热温度为500
°C ，在此最佳工况条件下 焦油产量小，飞灰及焦渣中重金属含量小，P (二嗯英)低于〇. 1〇 ng/m3.
ktkp-073关键词：热解气化炉；热解气化；预热空气温度；过量空气系数
中图分类号：X705
文章编号：1001-6929(2017)09-1471-08文献标志码：A DOI ： 10. 13198/j. issn. 1001-6929. 2017. 02. 69
Gasification and Pyrolysis Characteristics of Household Garbage in a Rotary Kiln Gasifier
WEI Chao 12, XIA X u nfen g 1' , WANG Jinggang 2, WANG Lijun1 , LU Huiyu 2, ZHANG Ying1
1. State Environmental Protection Key Laboratory of Simulation and Control of Groundwater Pollution, Chinese Research Academy of Environmental Sciences，Beijing 100012, China
2. College of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China
房产电商
Abstract ： Fixed-bed gasification has low gas heat value, low gasification efficiency, small fuel scope and complex pretreatment at room temperature. The influence of different preheated air temperature and excess air coefficient for municipal solid waste in a sm all, rotary kiln pyrolysis gasifier was studied with the control variable method. The result showed that the preheated air temperature rising is helpful for pyrolysis and gasification, but there are some limitations. When the temperature exceeded 600 °C, the garbage gasification gas decreased obviously. The garbage reached the maximum value and gasification efficiency and minimized the tar yield when the excess air coefficient was 0. 4. The heavy metal contents in slag, fly ash and garbage were investigated at the conditions of excess air coefficient 0. 4 and air preheating temperature 500 °C. The lead content in fly ash was much higher than the value in GB 18598-2001 Standard for Pollution Control on the Security Landfill Site for Hazardous Wastes , indicated a need for processing before being emitting. Dioxin sampling analysis results were below the value in GB 18485-2014 Standard for Pollution Control on the Municipal Solid Waste Incineration. The results showed that the best excess air coefficient of the rotary kiln pyrolysis gasification process was 0. 4，and the optimum air preheating temperature was 500 °C. Under the optimum conditions, the tar production, fly ash and coke slag heavy metal content was small, and dioxin levels were less than 0. 1 ng/m3.
回转窑热解气化炉处理生活垃圾特性
韦超〃，夏训峰1#，王京刚2，王丽君\吕慧瑜2，张颖
开放info共享平台Keywords ： pyrolysis and gasification furnace ； pyrolysis and热水泵机械密封
收稿日期：2016-10-23 修订日期：2017-06-06基金项目：国家科技重大专项（2〇l 5ZX 〇7l 〇3_0〇7_〇3)
作者简介：韦超（1989-)，男，山东临沂人，wcgd523090@163.
输液恒温器*责任作者，夏训峰（1968-)，男，浙江苍南人，研究员，博士，主要从事农 村生活污染控制技术研究，xiaxunfengg@ sina. com gasification ； preheated air temperature ； excess air coefficient 目前，城市生活垃圾的处理扶术主要有填埋、 堆肥、热处置i 大技术[1其中主要的热处置技术
豫公网安备41160202000603
站长QQ:729038198
关于我们
投诉建议