黑龙江交通科技
扩音喇叭
HEILONGJIANG JIAOTONG KEJI
2020年第6期(总第317期)
No . 6,2020(Sum No . 3 17)
张宏宇
(山西省交通建设工程质量检测中心(有限公司),山西太原030032)
摘要:通过对不同条件下海砂氯离子含量进行检测,系统性的分析研究了不同水浴温度、不同浸泡时间、不同水砂比以及不 同淡化处理措施对氯离子检测结果的影响,以得出更优的氯离子检测方法和施工现场快速淡化处理措施。研究表明:升高水 浴温度、延长浸泡时间、提高水砂比均能够促进氯离子析出,提高氯离子含量检测准确性,但促进效果只在一定范围内比较显 著;淘洗法和水冲法可以快速有效的解决施工现场海砂氯离子的淡化处理问题。关键词:海砂;氯离子;检测;淡化
中图分类号:U417.1 文献标识码:A 文章编号:808 - 3383(2727)76 - 0054 - 02
音频延时器Study on the detection technology of
chloride ions io sea sand and its rapiO desalioahon trectmeni
ZHANG Hong - yu
(Shanxi Transportation Construction Engineering Qualit/ Inspection Center(Lth. ) ,Taiyuan ,Shagxi ,630036)
android电视Abstract : By measuring the chloride content of see sand under different conditions , the eCects of different bath temperatures , different
soaling times , different water sand ratios and different desaOnation Weatwent measpres on the detection usp O s were systematicaly ana lyzed. Id order te oOtain a better met/oO of chOUde ion detection and rapin desalnation Weatwent measpres on the construction site.
The results show that increasing the bath temperature , lendthening the soaling time and increasing the ratio of water sand can promote chloride ion precipitation and iniprove the accoracy of chloride ion content detection , but the promotion effect is only sidnificaat in a
certain range ;Tap washing method and water flushing method can quichly and effectively solve the problem of desalnation Weatwent of seawater chloriPe ions in construction sites.
Keywonit :Sec sand ;calorine ions ;Testing ;Desalnation
试验选取了珠海横石基沙滩海水浸泡的海砂。试验方法选用《水运工程混凝土试验检测技术 规程》(JTS/T 236 -2214)海砂中氯离子含量快速 测定法,即氯离子选择电极法,尽可能排除人为因 素干扰。
2试验设计和试验结果
21 水浴温度对检测结果的影响
(8)试验设计① 称取烘干到恒重的海砂样品5份,每份525 g,贴上标签备用。
② 分别量取525 ml 的蒸憎水倒入装有海砂样 品的带盖容器中,开始计时。
③ 分别检测水浴温度为22 C 、42 C 、66 C 、85 C 、85 C 下浸泡2 h 的海砂氯离子含量,测试前
柴油脱>电磁水泵
8 min,用玻璃棒搅拌三次,每次间隔5 min 。
④每个样品进行两次平行试验,取算术平均 值,结果保留5.205 058%。
(2)结果分析
表8为不同温度浸泡下样品氯离子检测结果。
表1不同温度浸泡下样品氯离子检测结果
水浴温度C
dic系统20 40 66 85105氯离子含量%
5. 2866 66 5. 5896 55 5 . 222 466 5. 200 632
0.205 556
为了直观分析水浴温度对样品测试结果的影
响,见图8)
从表8可以算出,样品的氯离子含量检测结果从 42 C 的5.214 655% 提高到 66 C 的5.222 426% ,增 长率为141%,而从66 C 提高到85 C 的增长率仅为 81%。从图8中也可以看出:随着浸泡水浴温度的 升高,氯离子含量有增大趋势,但是在65 C 以后,这 种增长趋势变得不太明显。
收稿日期:2020 - 01 -14
作者简介:张宏宇(887 -),男,山西省太原市人,本科,工程师)
• 52 •