二效升膜蒸发器在草甘膦母液浓缩系统的应用_颜守保

2008年第15卷第1期
化工生产与技术ChemicalProductionandTechnology!!!!!!"!"!!!!!!"
!"经验交流收稿日期:2007-12-24
草甘膦是高效、低毒、低残留、广谱性除草剂。因
其性能优越而受到国内外众多企业的关注,并在最
近几年内纷纷向草甘膦行业投资。亚氨二乙酸
(IDA)法生产草甘膦,工艺稳定、收率高、三废排放
少,且可得到固体草甘膦,因而发展迅速。
随着草甘膦市场需求的日益增加,某公司采用
IDA法生产草甘膦的产量也在不断扩大,所产生的
母液量也日趋庞大。为了使草甘膦母液得到有效的
利用,避免将母液直接排放给环境造成的污染,该公
司将草甘膦母液蒸发浓缩,制成质量分数10%的草
甘膦水剂出售。在蒸发器的选择方面,从工艺要求和
设备选型的经济性和合理性进行考虑,选用了升膜
蒸发器。
升膜蒸发器具有效率高、蒸发时间短等优点,尤
其适应于热敏性较高、粘度较小的溶液[1]。在升膜蒸
发器的运行过程中,蒸汽消耗的费用是蒸发过程的
主要费用,二次蒸汽的利用是节约蒸汽行之有效的
方法[2]。考虑经济上合理性、技术上可操作性和安装
场地的可行性,选择了二效升膜蒸发器的流程。1工艺流程草甘膦母液浓缩用二效升膜蒸发器流程如图1所示。质量分数为4%的草甘膦母液料液经流量计顺次流过第1效、第2效升膜蒸发器,由第2效出来的浓缩液即为完成液,进入成品贮罐。而加热蒸汽通入第1效管束间放热冷凝后,经冷凝水排除器排出。具
有一定温度的料液由第1效蒸发器底部进入,到加热管内迅速沸腾汽化,生成的二次蒸汽在管内高速上升,而溶液被上升的蒸汽在加热管内高速上升所带动,沿着加热管内壁被拉成膜状迅速上升,并在上升过程中溶剂继续蒸发,二次蒸汽与浓缩的料液进
入第1效分离器内进行分离,二次蒸汽由分离器上
部进入第2效的加热室,放热冷凝后,经冷凝水排除
器排出;第1效分离器底部出来的初浓缩液由第2
效蒸发器底部吸入,进入加热管内迅速沸腾汽化,生
成二次蒸汽与再浓缩料液进入第2效分离器内分
离,蒸汽经过换热器凝结成水,进入废水储槽,浓缩
料液由分离器底部流入草甘膦母液的成品贮罐。
二效升膜蒸发器流程的工艺参数如表1。二效升膜蒸发器在草甘膦母液浓缩系统的应用
颜守保
(安徽氯碱化工集团,合肥230011)
摘要介绍了二效升膜蒸发器在草甘膦母液浓缩系统中的应用,可将草甘膦的质量分数
4%和母液蒸发浓缩制成质量分数10%的草甘膦水剂出售。通过增设料液预热器、
适当提高生蒸汽压力和提高稳定真空度,强化了升膜蒸发器生产能力。说明了操作中应注意的
事项,升膜蒸发器的操作要点。
关键词升膜蒸发器;草甘膦;母液;应用
中图分类号TQ457.2+6文献标识码A文章编号1006-6829(2008)01-0051-
02
・51・
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!表1草甘膦母液二效升膜蒸发器流程的工艺参数实际生产中选用了2台40m2换热器,自生产
以来,非常稳定。2蒸发能力的提高措施
2.1增设料液预热器
通入升膜蒸发器的生蒸汽进入第1效管束间放
热冷凝后,从蒸发器的下部排出。实际运行过程中,
生蒸汽不能完全利用,仍有大量的热蒸汽随着冷凝
管式直线电机水一起排出蒸发器外部。
利用生蒸汽通过管壳后的余热作为热源,在料
液进入第1效升膜蒸发器前增设预热器,把料液预
热到更高的温度,这样不仅可以充分利用热源、
避免浪费,而且可以减少蒸发器负荷、
缩短蒸发时间,有利于蒸发器生产能力的提高[3]。2.2适当提高生蒸汽压力
若进入第1效升膜蒸发器的蒸汽压力过低,液
体进入管内的预热段将增长,这就相应地缩短了环
状流段的薄膜蒸发距离,将导致传热量不够而使生
产能力下降或出料浓度达不到要求。因此,在一定范
围内,适当提高加热蒸汽的压力,会使蒸汽与物料之
间的温度差增加,即传热量增大,增加蒸发速度。但
蒸汽压不能过高,否则会使加热管出现“干壁区”反
而降低传热系数值,还会引起出料含量过高,易造成氢氧化锰
出料管堵塞,影响正常生产[4]。2.3提高和稳定真空度
升膜蒸发器的真空度越高,料液的沸点越低,冷
热流体的温度差的平均值越大,传热效果就越好。
同时在真空下,在下部进口处产生汽泡的过热温度超
过从膜内传热的温差,故蒸发完全能在膜表面进行。
在实际操作过程中应设法做到真空系统要独立,不宜与其他单元操作共用,否则真空度不稳定,会显著
影响物料沸点和水量蒸发,并且因真空度的变动,使
得操作频繁且不易控制[5]。
3操作注意事项
(1)进料前蒸汽系统需要先抽真空,当系统真空
稳定后才能进料,这样做是为了防止雾泡的产生;开
始进料量要小,一般按实际进料量的50%~70%,然
后打开蒸汽阀门使物料迅速升温,迅速升温的目的
是迫使物料迅速蒸发,防止物料在未蒸发前产生大
量雾泡。(2)为了防止操作过程中产生“
干管”现象,蒸发器接真空系统后,要先进料、后开加热蒸汽。
发烟筒(3)由于升膜蒸发器的缺点是单程浓缩比有限,通常为70%,不许超过80%。如果浓缩比过高,则因料液少,管壁湿润性差,形成固体溶质粘附在壁上的“干管”现象,不仅增加热阻,而且堵塞加热管,为了防止升膜蒸发器结垢,通常料液最终的相对密度不超过1.08,粘度不超过0.5Pa・s,不许有结晶产生。(4)二效升膜蒸发器适合连续化生产,当进料量衡定、分料均衡时,一般不作调整,不能随意增大进料量、开大排料量。另外生蒸汽压力需求要衡定,只有给汽压力衡定,各效物料分配均衡,设备才能进入稳定的工作状态。
4结束语自从升膜蒸发器应用于草甘膦母液浓缩系统以来,节能效果显著,草甘膦水剂产品的生产成本显著下降,取得了较好的经济效益,同时开创了升膜蒸发器在草甘膦行业应用的先例,具有较大的推广意义。参考文献[1]张乃慧,林自扬.从Q=K・S・Δt公式入手提高烧碱蒸发生产能力[J].氯碱工业,2003,3:29-31.[2]张建国,张英,李成丽.升膜蒸发器在天然碱制烧碱行业中
的应用[J].化学工业与工程技术,2000,3(21):36-37.[3]刘殿宇.三效蒸发器在谷氨酸二次母液上的应用[J].发酵科技通讯,2006,2(35):45-46.[4
]高呈光,秘爱民.提高双效降膜式蒸发器蒸发效率的探讨[J].中国乳业工业,1990,3(18):121-122.[5]李微,施小芳,林述英.升膜式蒸发器生产能力的提高[J].医药工程设计.2006,6(27):4-6.
颜守保二效升膜蒸发器在草甘膦母液浓缩系统的应用经验交流欢迎访问本刊网站www.hgscyjs.com・52・
ResearchonSynthesisTechnologiesofp-HydroxybenzaldehydeandItsApplicationProgress(End)
TaoJinhai,PeiWen
(CollegeofChemicalEngineeringandMaterials,ZhejiangUniversityofTechnology,Hangzhou310014)
Abstract:Applicationsofp-hydroxybenzaldehydeinthemedicine,pesticideandfoodspicesetc.areintroduced.ItisregardedthatReimer-Tiemannmethodwithadvantagesofrawmaterialscheapandeasyob
tained,operationsimple,reactionsteady,yieldandpurityhigh,isanindustrializedproductionmethodwithprospect.
Keywords:p-hydroxybenzaldehyde;Reimer-Tiemann;pcresol;reaction;application
PresentStatusandDevelopmentProspectofPolyamideatHomeandAbroad
WangHongzhuan,GaoXianming
(HenanShenmaNylonChemicalIndustryCompanyLimited,PingdingshanHennan467013)
Abstract:Developingcourseofpolyamide(PA)isreviewedandnewprogressofPAproductiontechnologyisintroduced.Itisestimatedthatpolyamideproductioncapacityanddemandwillreach4.6millionton
sand5.3milliontonsin2010throughtheanalysisofthemarket.Theindustrydevelopmentsuggestionisalsoputforward.ItisregardedthatdevelopmentofPAengineeringplasticsmuststartfromahighbeginning,largescalesoastoimprovetheproductqualityandenhancetheanti-riskabilityandquickenPAmodificationtechnologysearch.
Keywords:polyamide;nylon;PA6;PA66;presentstatus;progress
ConversionofAmmoniumChlorideandResourceComprehensiveUtilization
WangXudong,WuMin
(HaohuaSouthwestCo.Ltd,Zigong,Sichuan643000)
Abstract:Fromtheviewofsodaashandenvironmenta
lprotection,developmentpressureinfrontofthesodaashindustryandeffectofincreasingdemandofchlorineresourcerequirementareanalyzed,meanwhiledifferentprocessesandtechnicalroutesforammoniumchlorideconversionareintroduced,importantrealisticsignificanceandsocialsignificanceofammoniumchloridesourcearereviewed.Keywords:ammoniumchloride;sodaash;resource;comprehensiveutilization
DevelopmentProgressofPolyurethane-epoxyResinCompoundedMaterials
WangShuyan,ZengLiming,ZhaoQingmei
(MaterialCollege,WuhanUniversityofTechnology,Wuhan430070)
Abstract:Apreparationmethodofpolyurethane/ep
oxyresincompoundedmaterialinterpenetratingpolymernetworksisintroduced,enhancingmodificationasaconfigurationmaterialandfoamedmaterialareintroduced,itsdevelopmentprospectisalsoexpected.
Keywords:interpenetratingpolymernetwork;polyurethane,epoxyresin,modification
ImprovementontheStuffingBoxofPhenolicEpoxyResinDesolventingUnitGearPump
MaoGenxing,ChaiJingrong
(JiangshanJianghuanChemicalIndustryCo.Ltd,Jiangshan,Zhejiang324100)
Abstract:Inthedesolventingunitofphenolicepoxyresinproduction,gearpumpofthefallingfilmeva
烷基叔丁基醚poratorpumpandpelletizerfeedingrunsunderhightemperatureandhighviscidityandvacuum.Concerningwiththeproblemssuchasdifficultoperationofmanualjigger,badsealofstuffingbox,severeleakage,shortspanofthestuffing,andquickerabrasionofpump'saxis,reasonswhichcausesfortheseproblemsareanalyzed.Improvementismadeonthestuffingboxsealandbetterresultisobtainedincombinationwiththeapplicationofsealingofskeletonoilseal.
Keywords:gearpump;stuffingbox;seal;phenolicresin;improvementphenolicepoxyresin;improvement
ApplicationofDouble-EffectClimbing-filmEvaporatorinGlyphosateMotherLiquorConcentrationProcess
YanShoubao
(AnhuiChlor-alkaliChemicalGroupCompany,Hefei230011)
Abstract:Applicationsofdouble-effectclimbing-filmevaporatoringlyphosatemotherliquorconcentrationprocesswasintroduced.It
ispossibletoselltheglyphosatesolutionin10%masspartfromglyphosatesolutionin4%masspartandmotherliquidevaporation.Byadditionofliquidpreheaterapproach,properlyraisingthesteampressureandimprovimg,stablizimgvacuum,theproductioncapacityofclimbing-filmevaporatorisimproved.Attentionsintheoperationandkeypointsoftheclimbing-filmevaporatoroperationareexplained.
Keywords:climbing-filmevaporator;glyphosate;
motherliquor;application
AnalysisontheCausestoAffectSulfuricAcidColorandItsTreatment
PeiMingjie
(NorthCopperIndustryHoumasmelteringFactory,Houma,Shanxi043000)
Abstract:Assulfuricacid,preparedfromblowingfurnacefluegasinthecoppersulfideoresmelting,iseasytogetreddish,blackishandgreenish,reasonsarefoundthroughanalysisanddetection,flamecolorreactionandhangingexperimentincombinationwiththeproductionprocess.Correspondingcontrolmeasuresaretaken:reasonablefeeddistributioninthesmeltingsystem,strictandstandardprocessoperation,detailedmanagementandtimelycleanup
ofsediments,thusgoodresultsareobtained.
Keywords:sulfuricacid;color;analysis;treatment
ImprovementofProductionProcesstoRaiseNitrogenContentinLimeNitrogen
ZhouAnzhao
手动风量调节阀
(ZhejiangJuhuaCalciumCarbideCo.Ltd.Quzhou,Zhejiang324004)
Abstract:Reasonsaffectingnitrogencontentoflimenitrogen,whichisproducedbyconverterprocessisanalyzed.Productionprocessisoptimizedbyreasonablecatalystblending,feeddistributionsysteminnovationandsoon,chargecompositionandgas-generatingamountisstabilized,nitrogencontent
oflimenitrogenisraised,masspartofnitrogenisstablyover22.3%,andconsumptionislowered.Keywords:limenitrogen;converter;nitrogencontent;thindegree
ProblemsofNeodymiumPreparationthroughFluorideSystem
inFused-saltElectrolysisandItsImprovementSuggestions
LiuLiliang1,SunJinming1,ZhaoZhiping2,ChenJiguang3
(1.GanzhouYudongIndustry(Group)Co.Ltd;2.ResourceandEnvironmentalEngineeringInstitute,
JiangxiUniversityofTechnology;3.GanzhouMetallurgicalResearchInstitute,Ganzhou,Jiangxi341000)
Abstract:Severalprocessestoprepareneodymiumsuchaschloridefused-saltsystem,neodymiummagnesiumintermediatealloymethod,calciumthermalvacuumreductionneodymiumfluorinationmethodandfluoridesysteminfused-saltelectrolysisneodymiumoxidationmethodareintroduced.Theiradvantagesanddisadvantagesarealsoreviewed.Methodstoreduceandstablizethecarboncontentinthemetalneodymiumareputforward.Itissuggestedtoimprovethecurrentstrengthofasinglefurnaceandenlargethedeviceandincreasethevarietiestoferroalloy,cylinderanodeisusedinsteadofgraphiteelectrolyticcell,hanginggraphiteelectrodesinglephaseelectricheatingisusedinsteadofhangingkryptolheatingdevicefromoutside,whichprovidebetterresults.
Keywords:neodymium;fused-salt;electrolysis;fluoride;improvement
ThoughtonSoftwarePackageofChemicalProcessDesignBasedonComponentTechnology
ChenHua,MaoJianren
(ZhejiangEngineeringDesignCoLtd,Hangzhou310008)
Abstract:Developingneedof"chemicalprocessdesignsoftwarepackage"isanalyzedtoputforwardthetotaldesignthoughtofthe"softwarepackage"basedonmulti-agent(component)technology.Itisregardedthatthe"softwarepackage"shouldhavethekernelfunctionsofintelligencecreation,analyzingcomputation,designexpressionandmaterialstatistics;thesystemconfigurationiscomposedof3sub
systems(components)asprocessflowsimulation,pipingmaterialstatisticssystemoftheprocessanddesignmanagement.Suggestionsonthesoftwarepackagedevelopmentinthefutureareputforward.
Keywords:chemicalprocessdesign;softwarepackage;multi-agent

本文发布于:2024-09-20 23:17:13,感谢您对本站的认可!

本文链接:https://www.17tex.com/tex/3/103959.html

版权声明:本站内容均来自互联网,仅供演示用,请勿用于商业和其他非法用途。如果侵犯了您的权益请与我们联系,我们将在24小时内删除。

标签:蒸发器   草甘膦   蒸发   蒸汽   母液   浓缩
留言与评论(共有 0 条评论)
   
验证码:
Copyright ©2019-2024 Comsenz Inc.Powered by © 易纺专利技术学习网 豫ICP备2022007602号 豫公网安备41160202000603 站长QQ:729038198 关于我们 投诉建议